Analysis for inter turn stator fault with load variation in Induction Motor

Hakima Cherif, Madiha Maamir, Seif Eddine Chehaidia

Abstract

This paper investigates the impact of load variation on the diagnosis of inter-turn stator faults in induction machines. The proposed detection technique relies on the analysis of stator current using the discrete wavelet transform (DWT) in both normal and faulty states of the machine. The energy of the approximation and detail signals obtained from DWT provides valuable information about the machine's health and the severity of the inter-turn stator faults. Experimental tests were conducted using a dSpace 1104 signal card-based interface to study the load effects in detecting and diagnosing stator inter-turn short circuit faults in induction motor.

Keywords

on Motor, fault detection, diagnosis, Inter Turns Short Circuit Fault (ITSC), Discrete Wavelet Energy (DWE).

Full Text:

PDF

References

J. Cusido, et al., "Wavelet and PDD as fault detection techniques," Electric Power Systems Research, vol. 80, no. 8, 2010, pp. 915-924.

Y. Amara and G. Barakat, "Modeling and diagnostic of stator faults in induction machines using permeance network method," in Progress in electromagnetics research symposium, 2011.

A. Jacob, V. Jose, and D. Sebastian, "Stator fault detection in induction motor under unbalanced supply voltage," in Emerging Research Areas: Magnetics, Machines and Drives (AICERA/iCMMD), 2014 Annual International Conference on, 2014. IEEE.

H. Cherif, A. Benakcha, I. Laib, S. E. Chehaidia, A. Menacer, B. Soudan, and A. G. Olabi, "Early detection and localization of stator inter-turn faults based on discrete wavelet energy ratio and neural networks in induction motor," Energy, vol. 212, 2020, p. 118684.

S. Grubic, et al., "A survey on testing and monitoring methods for stator insulation systems of low-voltage induction machines focusing on turn insulation problems," IEEE Transactions on Industrial Electronics, vol. 55, no. 12, 2008, pp. 4127-4136.

J.-H. Jung, J.-J. Lee, and B.-H. Kwon, "Online diagnosis of induction motors using MCSA," IEEE Transactions on Industrial Electronics, vol. 53, no. 6, 2006, pp. 1842-1852.

J. Penman, et al., "Detection and location of interturn short circuits in the stator windings of operating motors," IEEE Transactions on Energy Conversion, vol. 9, no. 4, 1994, pp. 652-658.

M. Arkan, D. Perović, and P. Unsworth, "Online stator fault diagnosis in induction motors," IEE Proceedings-Electric Power Applications, vol. 148, no. 6, 2001, pp. 537-547.

S. Cheng, P. Zhang, and T. G. Habetler, "An impedance identification approach to sensitive detection and location of stator turn-to-turn faults in a closed-loop multiple-motor drive," IEEE Transactions on Industrial Electronics, vol. 58, no. 5, 2011, pp. 1545-1554.

S. Nandi, "Detection of stator faults in induction machines using residual saturation harmonics," IEEE Transactions on Industry Applications, vol. 42, no. 5, 2006, pp. 1201-1208.

S. M. Cruz and A. M. Cardoso, "Multiple reference frames theory: A new method for the diagnosis of stator faults in three-phase induction motors," IEEE Transactions on Energy Conversion, vol. 20, no. 3, 2005, pp. 611-619.

J. Cusido, et al., "Fault detection in induction machines using power spectral density in wavelet decomposition," IEEE Transactions on Industrial Electronics, vol. 55, no. 2, 2008, pp. 633-643.

A. Mohanty and C. Kar, "Fault detection in a multistage gearbox by demodulation of motor current waveform," IEEE Transactions on Industrial Electronics, vol. 53, no. 4, 2006, pp. 1285-1297.

S.H. Kia, H. Henao, and G.-A. Capolino, "Diagnosis of broken-bar fault in induction machines using discrete wavelet transform without slip estimation," IEEE Transactions on Industry Applications, vol. 45, no. 4, 2009, pp. 1395-1404.

H. Cherif, et al., "Stator inter turns fault detection using discrete wavelet transform," in Diagnostics for Electrical Machines, Power Electronics and Drives (SDEMPED), 2015 IEEE 10th International Symposium on, 2015. IEEE.

A. Khechekhouche, H. Cherif, A. Benakcha, A. Menacer, S. E. Chehaidia, and H. Panchal, "Experimental diagnosis of inter-turns stator fault and unbalanced voltage supply in induction motor using MCSA and DWER," Periodicals of Engineering and Natural Sciences, vol. 8, no. 3, 2020, pp. 1202-1216.

A. Allal, A.Khechekhouche, Diagnosis of induction motor faults using the motor current normalized residual harmonic analysis method. International Journal of Electrical Power and Energy Systems. 2022, vol. 141, 108219. https://doi.org/10.1016/j.ijepes.2022.108219

DOI: http://dx.doi.org/10.47238/ijeca.v8i1.215

Refbacks

  • There are currently no refbacks.